effect of partial replacement of sand with quarry dust on the

  • Effect of partial replacement of Sand with Quarry dust

    Effect of partial replacement of Sand with Quarry dust on strength of Flyash based Geopolymer Concrete composites mixes by replacing sand with quarry dust in different proportions from 0% to

  • Effect of partial replacement of Sand with Quarry dust

    In the contemporary development of concrete technology, Geopolymer concrete plays an essential role especially in the production of precast structural components and brick blocks It performes as an alternative material to the existing most expensive

  • Effects of The Total and Partial Replacement of Sharp

    Previous research carried out on this shows positive results and hence quarry dust has very recently gained good attention to be used as an effective filler material instead of sharp sand This project will investigate the effect of the total and partial replacement of sharp sand with quarry dust on concrete

  • (PDF) Effects of Partial Replacement of Fine Aggregate

    The results of the study also indicates that quarry dust can be utilised as partial replacement material to sand, in the presence of silica fume or fly ash, to produce concretes with fair ranges

  • PARTIAL REPLACEMENT OF SAND BY QUARRY DUST IN

      partial replacement of sand by Quarry dust by 20%, 30%, 40% and 50% The compressive strength of concrete cubes are obtained after 7 and 28 days of curing This experimental study shows that the concrete made with quarry dust might not be as workable as normal concrete but it gives higher strength than the conventional concrete

  • (PDF) Partial Replacement of Sand by Quarry Dust in

    International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 22503153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L Chauhan, Raju ABondre Assistant Professor P I G C E Nagpur Abstract The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of buildings and other

  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

      to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete 12 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete The introduction of quarry dust for mixing is limited due to its high fineness

  • Partial Replacement of Fine Aggregates with Quarry Dust

      river sand Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations

  • (PDF) Optimum Mix of Quarry Dust as Partial

    The effect of quarry dust on the flexural strength of concrete has been experimentally studied and reported in this paper with partial replacement of river sand by quarry dust

    5
  • THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT

      THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT WITH BONE ASH AND WOOD ASH IN CONCRETE 13 Department of Civil Engineering, Federal University of Agriculture, Abeokuta, NIGERIA ABSTRACT: The indiscriminate dumping of agro waste in the environment has brought about the need for adequate, safe disposal and recycling of such waste

  • Effect of partial replacement of Sand with Quarry dust

    In the contemporary development of concrete technology, Geopolymer concrete plays an essential role especially in the production of precast structural components and brick blocks It performes as an alternative material to the existing most expensive

  • CiteSeerX — Partial Replacement of Sand with Quarry

    This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand

  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

      to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete 12 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete The introduction of quarry dust for mixing is limited due to its high fineness

  • Partial Replacement of Sand with Quarry Dust in

    Granite fines or rock dust is a byproduct obtained during crushing of granite rocks and is also called quarry dust In recent days there were also been many attempts to use Fly Ash, an industrial by product as partial replacement for cement to have higher workability, long term strength and to make the concrete more economically available

  • Partial Replacement of Fine Aggregates with Quarry Dust

      river sand Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations

  • (PDF) Optimum Mix of Quarry Dust as Partial

    The effect of quarry dust on the flexural strength of concrete has been experimentally studied and reported in this paper with partial replacement of river sand by quarry dust from 375 to 27

  • Optimum Mix of Quarry Dust as Partial Replacement of

    Different ratios like 100:0, 90:10, 80:20, 70:30, 60:40 0:100 (quarry dust :sand) for M20 grade of concrete was cast and the strength parameters were studied Based on the strength the optimum

  • [PDF] Effect of Replacement of Natural Sand by

    There is a need to identify suitable alternative material from industrial waste in place of river sand The utilization of quarry dust which is a waste material has been accepted as building material in many countries for the past three decades The effect of w/c ratio on hardened properties of ordinary concrete with partial replacement of natural sand by manufactured sand is investigated

  • STUDY OF PARTIAL REPLACEMENT OF FINE AGGREGATE

      with quarry dust as a partial replacement of fine a ggregate, the following conclusion can be drawn: 1 The compressive strength of concrete is i use of quarry dust up to 10% replacement of sand F rom 10% there is decrease in compressive strength 2 The split tensile strength concrete is

  • THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT

      THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT WITH BONE ASH AND WOOD ASH IN CONCRETE 13 Department of Civil Engineering, Federal University of Agriculture, Abeokuta, NIGERIA ABSTRACT: The indiscriminate dumping of agro waste in the environment has brought about the need for adequate, safe disposal and recycling of such waste

  • Effect of Partial Replacement of Sand With Quarry

      This work investigated the effect of partial replacement of sand with quarry dust on the compressive strength, flexural strength, split tensile strength and water absorption of sandcrete blocks River sand was replaced with quarry dust at percentages ranging from 0 to 40 at cement/combined aggregate ratio of 1: 6 The blocks were moulded using a Rosa Commetta block laying machine and

  • CiteSeerX — Partial Replacement of Sand with Quarry

    This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand

  • Partial Replacement of Sand by Quarry Dust in Concrete

      Partial Replacement of Sand by Quarry Dust in Concrete Sumit L Chauhan, Raju ABondre Assistant Professor P I G C E Nagpur Abstract The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand

  • An Experimental Study on Partial Replacement of Sand

      River sand is costly due to transportation, large scale depletion of resources and enforcement regulations Quarry dust can be used as an alternative to the river sand Cost analysis shows that there is 40% savings if quarry dust is used instead of sand IllangoanR1 [2000] has done a study on100% replacement of sand by quarry dust in concrete

  • An Experimental study on Effects of Quarry Dust as

    The quarry dust is used to manufacturing of hollow blocks The program involves casting and testing cube specimens in each set consisting of 3 cubes The cubes were casted using standard cubes of 150 mm × 150 mm × 150 mm Specific gravity of sand and quarry dust of

  • Partial Replacement of Sand with Quarry Dust in

    Granite fines or rock dust is a byproduct obtained during crushing of granite rocks and is also called quarry dust In recent days there were also been many attempts to use Fly Ash, an industrial by product as partial replacement for cement to have higher workability, long term strength and to make the concrete more economically available

  • Optimum utilization of Quarry dust as partial

    River sand is most commonly used fine aggregate in concrete but due to acute shortage in many areas, availability, cost environmental impact are the major concern (Ahmed etal, 1989) To overcome from this crisis, partial replacement of sand with quarry dust can be an economic alternative

  • Suitability of Quarry Dust as a Partial Replacement of

    Large quantity of the quarry dust gets produced annually in the quarries during the extraction of the crushed coarse aggregate As a result, disposal problems of this material gain significant momentum as these disturb environmental systems also Nowadays many of the countries like India is facing problems of ban on the extraction of sand and lacunae in procuring of fine aggregate, which is

  • Experimental Investigation on Quarry Dust as a Partial

      be casted by a partial replacement of natural fine aggregate in dry concrete mix and quarry dust will be used as a fine aggregate The gravity quarry dust is replaced by sand varying different percentage (0%, 15%, 30%, 45%, 60% 75%) then test data of quarry dust concrete will be compared with test data from a standard concrete

  • THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT

      THE EFFECT OF PARTIAL REPLACEMENT OF CEMENT WITH BONE ASH AND WOOD ASH IN CONCRETE 13 Department of Civil Engineering, Federal University of Agriculture, Abeokuta, NIGERIA ABSTRACT: The indiscriminate dumping of agro waste in the environment has brought about the need for adequate, safe disposal and recycling of such waste

  • Effect of Partial Replacement of Sand With Quarry

      This work investigated the effect of partial replacement of sand with quarry dust on the compressive strength, flexural strength, split tensile strength and water absorption of sandcrete blocks River sand was replaced with quarry dust at percentages ranging from 0 to 40 at cement/combined aggregate ratio of 1: 6 The blocks were moulded using a Rosa Commetta block laying machine and

  • Effect of Partial Replacement of Sand With Quarry

    This work investigated the effect of partial replacement of sand with quarry dust on the compressive strength, flexural strength, split tensile strength and water absorption of sandcrete blocks River sand was replaced with quarry dust at percentages ranging from 0 to 40 at

  • Partial Replacement of Sand by Quarry Dust in Concrete

      Partial Replacement of Sand by Quarry Dust in Concrete Sumit L Chauhan, Raju ABondre Assistant Professor P I G C E Nagpur Abstract The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand

  • An Experimental Study on Partial Replacement of Sand

      River sand is costly due to transportation, large scale depletion of resources and enforcement regulations Quarry dust can be used as an alternative to the river sand Cost analysis shows that there is 40% savings if quarry dust is used instead of sand IllangoanR1 [2000] has done a study on100% replacement of sand by quarry dust in concrete

  • Effect of Quarry Dust on Class C Fly Ash Concrete

      investigation presents the experimental work of partial replacement of cement by class C fly ash along with quarry dust for sand The cement is replaced by fly ash at 10%, 20%, 30%, 40% with quarry dust by 0%, 25%, 50% of concrete specimens were prepared The specimens are curing at the ages of 7, 28, 60 days and tested for compressive and split

  • The effect of using quarry dust as a sand replacement

    The effect of using quarry dust as a sand replacement material on compressive strength of concrete / in such a situation the quarry dust can be an economic alternative to the river sand quarry dust can be defined as residue, tailing or other nonvoluble waste material after the extraction and processing of rocks to form fine particles less

  • Suitability of Quarry Dust as a Partial Replacement of

    Large quantity of the quarry dust gets produced annually in the quarries during the extraction of the crushed coarse aggregate As a result, disposal problems of this material gain significant momentum as these disturb environmental systems also Nowadays many of the countries like India is facing problems of ban on the extraction of sand and lacunae in procuring of fine aggregate, which is

  • Quarry Dust Uses in a Construction Project

      Quarry dust uses is not limited to highway projects, in construction projects that involves homes building, it is fast becoming popular too Partial replacement of sand with quarry dust will make good concrete that is well desired in residential

  • Projects Department of Civil, Construction and

    Comparative analysis on the effects of partial replacement of sand with quarry dust sourced from two different quarries on the properties of concrete DrEngManguriu EN2511729/2010: Comparative study of pine tree extract admixture and the conventional pozzolith admixture on the properties of fresh and hardened concrete MrBOdero/ DrEng

  • Effect of coal bottom ash as partial replacement of

      Ghafoori and Bucholc (1996) investigated the effect of lignite based bottom ash as sand replacement and impact of use of water reducing admixtures on properties of fresh structural concrete mixtures with varying cement content of 500 lb/yd 3, 600 lb/yd 3, 700 lb/yd 3, and 800 lb/yd 3 They noted that when identical water cement ratios were used